Low-cost ternary composite photocatalysts consisting of TiO2, kaolinite and cement for an efficient organic waste decontamination in water

Kohobhange Karunadasa, Pannilage Madhushanka, Chinthan Manoratne

Article ID: 4510
Vol 7, Issue 1, 2024

VIEWS - 1898 (Abstract)

Abstract


The present study demonstrates the fabrication of heterogeneous ternary composite photocatalysts consisting of TiO2, kaolinite, and cement (TKCe),which is essential to overcome the practical barriers that are inherent to currently available photocatalysts. TKCe is prepared via a cost-effective method, which involves mechanical compression and thermal activation as major fabrication steps. The clay-cement ratio primarily determines TKCe mechanical strength and photocatalytic efficiency, where TKCe with the optimum clay-cement ratio, which is 1:1, results in a uniform matrix with fewer surface defects. The composites that have a clay-cement ratio below or above the optimum ratio account for comparatively low mechanical strength and photocatalytic activity due to inhomogeneous surfaces with more defects, including particle agglomeration and cracks. The TKCe mechanical strength comes mainly from clay-TiO2 interactions and TiO2-cement interactions. TiO2-cement interactions result in CaTiO3 formation, which significantly increases matrix interactions; however, the maximum composite performance is observed at the optimum titanate level; anything above or below this level deteriorates composite performance. Over 90% degradation rates are characteristic of all TKCe, which follow pseudo-first-order kinetics in methylene blue decontamination. The highest rate constant is observed with TKCe 1-1, which is 1.57 h−1 and is the highest among all the binary composite photocatalysts that were fabricated previously. The TKCe 1-1 accounts for the highest mechanical strength, which is 6.97 MPa, while the lowest is observed with TKCe 3-1, indicating that the clay-cement ratio has a direct relation to composite strength. TKCe is a potential photocatalyst that can be obtained in variable sizes and shapes, complying with real industrial wastewater treatment requirements.


Keywords


TiO2; kaolinite; cement; composite photocatalyst; industrial wastewater treatment

Full Text:

PDF


References


Szczepanik B. Photocatalytic degradation of organic contaminants over clay-TiO2 nanocomposites: A review. Applied Clay Science. 2017; 141: 227-239. doi: 10.1016/j.clay.2017.02.029 Lofrano G, Rizzo L, Grassi M, et al. Advanced oxidation of catechol: A comparison among photocatalysis, Fenton and photo-Fenton processes. Desalination. 2009; 249(2): 878-883. doi: 10.1016/j.desal.2009.02.068 Lazar M, Varghese S, Nair S. Photocatalytic Water Treatment by Titanium Dioxide: Recent Updates. Catalysts. 2012; 2(4): 572-601. doi: 10.3390/catal2040572 Djafer L, Ayral A, Ouagued A. Robust synthesis and performance of a titania-based ultrafiltration membrane with photocatalytic properties. Separation and Purification Technology. 2010; 75(2): 198-203. doi: 10.1016/j.seppur.2010.08.001 Damodar RA, You SJ, Chou HH. Study the self cleaning, antibacterial and photocatalytic properties of TiO2 entrapped PVDF membranes. Journal of Hazardous Materials. 2009; 172(2-3): 1321-1328. doi: 10.1016/j.jhazmat.2009.07.139 Liu L, Liu Z, Bai H, et al. Concurrent filtration and solar photocatalytic disinfection/degradation using high-performance Ag/TiO2 nanofiber membrane. Water Research. 2012; 46(4): 1101-1112. doi: 10.1016/j.watres.2011.12.009 Bedford NM, Pelaez M, Han C, et al. Photocatalytic cellulosic electrospun fibers for the degradation of potent cyanobacteria toxin microcystin-LR. Journal of Materials Chemistry. 2012; 22(25): 12666. doi: 10.1039/c2jm31597a Tennakone K, Tilakaratne CTK, Kottegoda IRM. Photocatalytic degradation of organic contaminants in water with TiO2 supported on polythene films. Journal of Photochemistry and Photobiology A: Chemistry. 1995; 87(2): 177-179. doi: 10.1016/1010-6030(94)03980-9 Tennakone K, Kottegoda IRM. Photocatalytic mineralization of paraquat dissolved in water by TiO2 supported on polythene and polypropylene films. Journal of Photochemistry and Photobiology A: Chemistry. 1996; 93(1): 79-81. doi: 10.1016/1010-6030(95)04141-9 Kumara GRRA, Sultanbawa FM, Perera VPS, et al. Continuous flow photochemical reactor for solar decontamination of water using immobilized TiO2. Solar Energy Materials and Solar Cells. 1999; 58(2): 167-171. doi: 10.1016/S0927-0248(98)00200-1 Kibanova D, Trejo M, Destaillats H, et al. Synthesis of hectorite–TiO2 and kaolinite–TiO2 nanocomposites with photocatalytic activity for the degradation of model air pollutants. Applied Clay Science. 2009; 42(3-4): 563-568. doi: 10.1016/j.clay.2008.03.009 Papoulis D, Komarneni S, Panagiotaras D, et al. Halloysite–TiO2 nanocomposites: Synthesis, characterization and photocatalytic activity. Applied Catalysis B: Environmental. 2013; 132-133: 416-422. doi: 10.1016/j.apcatb.2012.12.012 Zhao D, Zhou J, Liu N. Characterization of the structure and catalytic activity of copper modified palygorskite/TiO2 (Cu2+-PG/TiO2) catalysts. Materials Science and Engineering: A. 2006; 431(1-2): 256-262. doi: 10.1016/j.msea.2006.06.001 Kameshima Y, Tamura Y, Nakajima A, et al. Preparation and properties of TiO2/montmorillonite composites. Applied Clay Science. 2009; 45(1-2): 20-23. doi: 10.1016/j.clay.2009.03.005 Machado LCR, Torchia CB, Lago RM. Floating photocatalysts based on TiO2 supported on high surface area exfoliated vermiculite for water decontamination. Catalysis Communications. 2006; 7(8): 538-541. doi: 10.1016/j.catcom.2005.10.020 Nishikiori H, Shindoh J, Takahashi N, et al. Adsorption of benzene derivatives on allophane. Applied Clay Science. 2009; 43(2): 160-163. doi: 10.1016/j.clay.2008.07.024 Chong MN, Lei S, Jin B, et al. Optimisation of an annular photoreactor process for degradation of Congo Red using a newly synthesized titania impregnated kaolinite nano-photocatalyst. Separation and Purification Technology. 2009; 67(3): 355-363. doi: 10.1016/j.seppur.2009.04.001 Mamulová Kutláková K, Tokarský J, Kovář P, et al. Preparation and characterization of photoactive composite kaolinite/TiO2. Journal of Hazardous Materials. 2011; 188(1-3): 212-220. doi: 10.1016/j.jhazmat.2011.01.106 Zhang GK, Ding XM, He FS, et al. Low-Temperature Synthesis and Photocatalytic Activity of TiO2 Pillared Montmorillonite. Langmuir. 2008; 24(3): 1026-1030. doi: 10.1021/la702649v Ding Z, Hu X, Yue PL, et al. Synthesis of anatase TiO2 supported on porous solids by chemical vapor deposition. Catalysis Today. 2001; 68(1): 173-182. doi: 10.1016/S0920-5861(01)00298-X Karunadasa KSP, Manoratne CH, Pitawala HMTGA, et al. A potential working electrode based on graphite and montmorillonite for electrochemical applications in both aqueous and molten salt electrolytes. Electrochemistry Communications. 2019; 108: 106562. doi: 10.1016/j.elecom.2019.106562 Karunadasa KSP, Rathnayake D, Manoratne C, et al. A binder‐free composite of graphite and kaolinite as a stable working electrode for general electrochemical applications. Electrochemical Science Advances. 2021; 1(4). doi: 10.1002/elsa.202100003 Rathnayake DT, Karunadasa KSP, Wijekoon ASK, et al. Low-cost ternary composite of graphite, kaolinite and cement as a potential working electrode for general electrochemical applications. Chemical Papers. 2022; 76(10): 6653-6658. doi: 10.1007/s11696-022-02314-w Madhushanka PMH, Karunadasa KSP, Gamini Rajapakse RM, et al. Low-cost composite electrode consisting of graphite, colloidal graphite and montmorillonite with enhanced electrochemical performance for general electroanalytical techniques and device fabrication. Chemical Papers. 2023; 78(1): 633-643. doi: 10.1007/s11696-023-03086-7 Rathnayake DT, Karunadasa KSP, Wijekoon ASK, et al. Polyaniline-conjugated graphite–montmorillonite composite electrode prepared by in situ electropolymerization for supercapacitor applications. Chemical Papers. 2023; 77(5): 2923-2928. doi: 10.1007/s11696-022-02646-7 Karunadasa KSP, Wijekoon ASK, Manoratne CH. TiO2-kaolinite composite photocatalyst for industrial organic waste decontamination. Next Materials. 2024; 3: 100065. doi: 10.1016/j.nxmate.2023.100065 Gunarathne PPB, Karunadasa KSP. Low-cost heterogeneous composite photocatalyst consisting of TiO2, kaolinite and MMT with improved mechanical strength and photocatalytic activity for industrial wastewater treatment. Insight - Mechanics. 2023; 6(1). doi: 10.18282/m.v6i1.597 Temenoff JS. Biomaterials: The Intersection of Biology and Materials science, 1st ed. Pearson prentice Hall; 2008. pp. 151-159. Alkaykh S, Mbarek A, Ali-Shattle EE. Photocatalytic degradation of methylene blue dye in aqueous solution by MnTiO3 nanoparticles under sunlight irradiation. Heliyon. 2020; 6(4): e03663. doi: 10.1016/j.heliyon.2020.e03663 Kasanen J, Salstela J, Suvanto M, et al. Photocatalytic degradation of methylene blue in water solution by multilayer TiO2 coating on HDPE. Applied Surface Science. 2011; 258(5): 1738-1743. doi: 10.1016/j.apsusc.2011.10.028 Al-Rawashdeh NAF, Allabadi O, Aljarrah MT. Photocatalytic Activity of Graphene Oxide/Zinc Oxide Nanocomposites with Embedded Metal Nanoparticles for the Degradation of Organic Dyes. ACS Omega. 2020; 5(43): 28046-28055. doi: 10.1021/acsomega.0c03608 Dharma HNC, Jaafar J, Widiastuti N, et al. A Review of Titanium Dioxide (TiO2)-Based Photocatalyst for Oilfield-Produced Water Treatment. Membranes. 2022; 12(3): 345. doi: 10.3390/membranes12030345 Karunadasa KSP, Manoratne CH. Microstructural view of anatase to rutile phase transformation examined by in-situ high-temperature X-ray powder diffraction. Journal of Solid State Chemistry. 2022; 314: 123377. doi: 10.1016/j.jssc.2022.123377 Sengyang P, Rangsriwatananon K, Chaisena A. Preparation of zeolite N from metakaolinite by hydrothermal method. Journal of Ceramic Processing Research. 2015; 16(1): 111-116. Křenek T, Kovářík T, Pola J, et al. Nano and micro-forms of calcium titanate: Synthesis, properties and application. Open Ceramics. 2021; 8: 100177. doi: 10.1016/j.oceram.2021.100177 Karunadasa KSP, Manoratne CH, Pitawala HMTGA, et al. Thermal decomposition of calcium carbonate (calcite polymorph) as examined by in-situ high-temperature X-ray powder diffraction. Journal of Physics and Chemistry of Solids. 2019; 134: 21-28. doi: 10.1016/j.jpcs.2019.05.023 Karunadasa KSP. Dehydration of Calcium Chloride as Examined by High-temperature X-ray Powder Diffraction. International Multidisciplinary Research Journal. 2019; 4: 37-43. Cho J, Waetzig GR, Udayakantha M, et al. Incorporation of Hydroxyethylcellulose-Functionalized Halloysite as a Means of Decreasing the Thermal Conductivity of Oilwell Cement. Scientific Reports. 2018; 8(1). doi: 10.1038/s41598-018-34283-0 Portia SAU, Srinivasan R, Elaiyappillai E, et al. Facile synthesis of Eu-doped CaTiO3 and their enhanced supercapacitive performance. Ionics. 2020; 26(7): 3543-3554. doi: 10.1007/s11581-020-03494-9 Ohtani B, Prieto-Mahaney OO, Li D, et al. What is Degussa (Evonik) P25? Crystalline composition analysis, reconstruction from isolated pure particles and photocatalytic activity test. Journal of Photochemistry and Photobiology A: Chemistry. 2010; 216(2-3): 179-182. doi: 10.1016/j.jphotochem.2010.07.024



DOI: https://doi.org/10.24294/jpse.v7i1.4510

Refbacks

  • There are currently no refbacks.


Copyright (c) 2024 Kohobhange Karunadasa, Pannilage Madhushanka, Chinthan Manoratne

License URL: https://creativecommons.org/licenses/by/4.0/

This site is licensed under a Creative Commons Attribution 4.0 International License.