.jpg)
_.jpg)
Experimental study on waste heat recovery characteristics of inorganic ceramic membrane flue gas
Vol 5, Issue 1, 2022
VIEWS - 307 (Abstract) 223 (pdf)
Abstract
The wet saturated flue gas discharged by coal-fired utility boilers leads to a large amount of low-temperature waste heat loss. Inorganic ceramic membrane is acid-base resistant and has strong chemical stability. It is an ideal material for recovering low-temperature waste heat from flue gas. The experiment of waste heat recovery of flue gas was carried out with inorganic ceramic membrane as the core, and the characteristic parameters of low-temperature flue gas at the tail of the boiler were analyzed; taking 316 L stainless steel as the comparative object, the strengthening effect of inorganic ceramic film on improving heat recovery power and composite heat transfer coefficient was discussed. The results show that the waste heat recovery of flue gas is mainly the evaporation latent heat recovery of water, accounting for about 90%; circulating water is used as cooling medium, and the waste heat recovery capacity of flue gas is stronger; compared with circulating water, when air is used as the cooling medium, the effect of inorganic ceramic membrane flue gas waste heat recovery is more significant, and the enhancement coefficient is as high as 9; increasing the flue gas flow is helpful to improve the heat recovery power and composite heat transfer coefficient; at the same time, inorganic ceramic membrane can also recover condensate with high water quality. The results of this paper can provide a reference for the application of inorganic ceramic membrane in flue gas waste heat recovery.
Keywords
Full Text:
pdfReferences
1. Pang L, Li R, Sun S, et al. Thermal analysis on the boiler performance of 1000 MW tower solar aided power generation unit. Proceedings of the CSEE 2017; 37(5): 1417–1426.
2. Wei M, Fu L, Zhao X, et al. Coal-fired boiler flue gas heat recovery system and its performance study. Journal of Engineering Thermophysics 2017; 38(6): 1157–1165.
3. Weber C, Gebhardt B, Fahl U. Market transformation for energy efficient technologies-success factors and empirical evidence for gas condensing boilers. Energy 2002; 27(3): 287–315.
4. Xiong Y, Tan H, Wang Y, et al. Pilot-scale study on water and latent heat recovery from flue gas using fluorine plastic heat exchangers. Journal of Cleaner Production 2017; 161(10): 1416–1422.
5. Liu H, Zhou X, Fu L. Heat transfer performance of direct-contact flue gas condensation heat exchanger. Heating Ventilation and Air Conditioning 2014; 44(9): 97–100.
6. Zhu K, Xia J, Xie X, et al. Total heat recovery of gas boiler by absorption heat pump and direct-contact heat exchanger. Applied Thermal Engineering 2014; 71(1): 213–218.
7. Yue M, Zhao S, Feron P, et al. Multichannel tubular ceramic membrane for water and heat recovery from waste gas streams. Industrial & Engineering Chemistry Research 2016; 55(9): 2615–2622.
8. Hu H, Tang G, Niu D. Wettability modified nano-porous ceramic membrane for simultaneous residual heat and condensate recovery. Scientific Reports 2016; 6(1): 27274.
9. Ma Y, Yang L, Lv J. Techno-economic comparison of three processes for boiler waste heat recovery. Journal of Chinese Society of Power Engineering 2017; 37(4): 321–328.
10. Wang Z, Zhang X, Li Z, et al. Evaluation of a flue gas driven open absorption system for heat and water recovery from fossil fuel boilers. Energy Conversion & Management 2016; 128(15): 57–65.
11. Wang T, Yue M, Qi H, et al. Transport membrane condenser for water and heat recovery from gaseous streams: Performance evaluation. Journal of Membrane Science 2015; 484(15): 10–17.
12. Jia H, Fu L, Zhang S. Open absorption heat pump and application in flue gas waste heat recovering. Chemical Industry and Engineering Progress 2013; 32(12): 18–25.
13. Wang Z, Zhang X, Han J, et al. Waste heat and water recovery from natural gas boilers: Parametric analysis and optimization of a flue-gas-driven open absorption system. Energy Conversion and Management 2017; 154(15): 526–537.
14. Chen H, Liu Y, Zhou Y. Experimental study on recycling water vapor from flue gas of thermal power plants using hollow fiber membrane. Thermal Power Generation 2017; 46(1): 100–105.
15. Chen H, Feng Y, Yang B, et al. Experimental research on performance of ceramic membrane module for water and waste heat recovery from flue gas. Thermal Power Generation 2019; 48(2): 45–52.
DOI: https://doi.org/10.24294/tse.v5i1.1529
Refbacks
- There are currently no refbacks.
This work is licensed under a Creative Commons Attribution-NonCommercial 4.0 International License.
This site is licensed under a Creative Commons Attribution-NonCommercial 4.0 International License.